Maintenance Of Electric Tricycle
Electric tricycle vehicle maintenance includes checking all screws, nuts are solid, performance is good, tires need to be replaced, mechanical systems are good, standard battery capacity, brush motor maintenance once a year. Specific maintenance as follows:
(1) vehicle full commissioning, check whether the electrical control circuit failure, electrical connector without damage, if any should be excluded in situ;
(2) adjust the front and rear brakes to ensure that brakes, flexible and reliable;
(3) the reliability of the handlebar steering, handlebars and front fork sliding phenomenon;
(4) battery checked regularly (once a month in the summer, winter once every 2-3 months) battery level is below the marking, if the exposed plate, add distilled water in a timely manner. (Note do not add acid, because each storage battery factory according to the ratio to adjust the electrolyte concentration, pH of acid will destroy the existing balance, causing pole plate corrosion affecting battery life.
(5) the rear axle transmission when used for the first time, to pay attention to add gear oil, after regular check rear axle gearbox has no oil leakage, sealing gasket damaged, missing phenomenon of lubricating oil, the timely replacement of gaskets, adding lubricant.
(6) transmission, motor sprocket, chain timing oil, such as wear should be replaced immediately, so as not to affect the use.
(7) vehicle bolt fastening on a regular basis again, check for loose and fall off, and on the appropriate antirust fluid, avoiding screws rust caused maintenance difficulties.
(8) the vehicle clean, try wipe clean.